Section 326 IAC 8-3-2 - Cold cleaner degreaser control equipment and operating requirementsAuthority: IC 13-14-8; IC 13-17-3-4; IC 13-17-3-11; IC 13-17-3-12
Affected: IC 13-17-3
Sec. 2.
(a) The owner or operator of a cold cleaner degreaser shall comply with the following control equipment and operating requirements: (1) Equip the degreaser with a cover.(2) Equip the degreaser with a device for draining cleaned parts.(3) Close the degreaser cover whenever parts are not being handled in the degreaser.(4) Drain cleaned parts for at least fifteen (15) seconds or until dripping ceases.(5) Provide a permanent, conspicuous label that lists the operating requirements in subdivisions (3), (4), (6), and (7).(6) Store waste solvent only in closed containers.(7) Prohibit the disposal or transfer of waste solvent in a manner that would allow greater than twenty percent (20%) of the waste solvent by weight to evaporate into the atmosphere.(b) The owner or operator of a cold cleaner degreaser subject to this subsection shall comply with the following additional control equipment and operating requirements: (1) Equip the degreaser with one (1) of the following control devices if the solvent is heated to a temperature of greater than forty-eight and nine-tenths (48.9) degrees Celsius (one hundred twenty (120) degrees Fahrenheit): (A) A freeboard that attains a freeboard ratio of seventy-five hundredths (0.75) or greater.(B) A water cover when solvent used is insoluble in, and heavier than, water.(C) A refrigerated chiller.(E) VOC emission control equipment operated in accordance with section 8(b)(3) of this rule.(2) Ensure the degreaser cover is designed so that it can be easily operated with one (1) hand if the solvent is agitated or heated.(3) If used, solvent spray must be:(A) performed in an enclosed chamber, with or without venting; or(B) a solid, fluid stream applied at a pressure that does not cause excessive splashing.Air Pollution Control Division; 326 IAC 8-3-2; filed Mar 10, 1988, 1:20 p.m.: 11 IR 2537; readopted filed Jan 10, 2001, 3:20 p.m.: 24 IR 1477; filed Jan 30, 2013, 12:33 p.m.: 20130227-IR-326070352FRAFiled 5/11/2021, 11:22 a.m.: 20210609-IR-326180542FRA