Section 334.55 - Permanent Removal from Service(a) General provisions. (1) Any owner or operator who intends to permanently remove an underground storage tank (UST) from service (by either removing the tank from the ground, abandoning the tank in-place, or conducting a permanent change-in-service) shall provide prior notice of this activity to the agency in accordance with § 334.6 of this title (relating to Construction Notification for Underground Storage Tanks (USTs) and UST Systems).(2) The procedures used in permanently removing the UST from service shall conform with accepted industry practices, and shall be in accordance with a code or standard of practice developed by a nationally recognized association or independent testing laboratory.(3) The permanent removal from service shall be conducted by qualified personnel possessing the appropriate skills, experience, competence, and, if applicable, any required license or certification to complete the activity in accordance with the provisions of this section and in a manner designed to minimize the possibility of any threats to human health and safety or the environment.(4) All USTs that are intended for permanent removal from service shall be emptied of all regulated substances and accumulated sludges or residues, and shall be purged of all residual vapors in accordance with accepted industry procedures commonly employed for the stored regulated substance.(5) The handling, transportation, and disposal of any regulated substances removed from a UST system, and any contaminated soils, backfill material, groundwater, wash water, or other similar materials removed from the system or facility, shall be conducted in a safe and environmentally sound manner, and shall be in accordance with all applicable federal, state, and local regulations in effect for the type, volume, contaminant concentration, and classification of the removed material.(6) As part of the required procedure for the permanent removal of any UST system from service, the owner or operator shall determine whether or not any prior release of a stored regulated substance has occurred from the system. (A) This determination shall be performed subsequent to the submittal of notification to the agency as prescribed in § 334.6 of this title, but prior to completion of the permanent removal from service.(B) This determination shall be made by visual inspection of the area in and immediately surrounding the excavation zone for any above-ground releases and for any exposed below-ground releases, and by using one or both of the following methods or procedures: (i) the continual operation (through the time that the stored regulated substances are removed from the UST system) of one or more of the external release monitoring and detection methods operating in accordance with §334.50(d)(5) - (8) of this title (relating to Release Detection); or(ii) the performance of a comprehensive site assessment in accordance with the requirements of subsection (e) of this section.(C) Any methods or procedures used to make this determination shall be capable of detecting any prior release of stored regulated substances from any portion of the UST system.(D) Upon completion of this determination, the owner or operator shall: (i) report any confirmed or suspected releases to the agency and comply with all applicable release investigation and corrective action requirements, as prescribed in Subchapter D of this chapter (relating to Release Reporting and Corrective Action);(ii) prepare or assemble the detailed written records of this determination, which shall include the methods, procedures, results, and names, addresses, and telephone numbers of the persons involved in conducting such determination. Such records shall be maintained in accordance with the applicable provisions in subsection (f) of this section, and a copy of such records shall be filed with the agency in conjunction with the applicable tank registration requirements of § 334.7 of this title (relating to Registration for Underground Storage Tanks (USTs) and UST Systems).(7) For a UST to be considered permanently out-of-service, the owner or operator shall either remove the tank from the ground in accordance with subsection (b) of this section, abandon in-place and fill the tank with an acceptable solid inert material in accordance with subsection (c) of this section, or conduct a permanent change-in-service in accordance with subsection (d) of this section. Unused tanks (i.e., tanks at facilities which are closed or out-of-business) shall be considered temporarily out-of-service, and shall be subject to the provisions of § 334.54 of this title (relating to Temporary Removal from Service), unless they have been permanently removed from service in accordance with this section.(8) The requirements in this section are applicable to all USTs which are permanently removed from service on or after September 29, 1989.(9) When directed by the executive director, the owner and operator of a UST system permanently closed before September 29, 1989, must assess the excavation zone and close the UST system in accordance with this subchapter if releases from the UST may, in the judgment of the executive director, pose a current or potential threat to human health and the environment.(b) Removal from the ground. In addition to the requirements of subsection (a) of this section, the following requirements shall be applicable for the removal of USTs from the ground.(1) Except as provided under paragraph (2) of this subsection, tanks shall be properly emptied, cleaned, and purged of vapors prior to removal from the ground, in accordance with accepted industry procedures commonly employed for the stored regulated substance.(2) When an owner or operator can demonstrate good cause for removal of a tank from the ground prior to emptying, cleaning, or purging the vapors, the owner or operator shall obtain approval from the manager of the appropriate regional office (or the manager's designated representative) prior to proceeding with the removal. In this situation, the tank removal shall be accomplished only under the direct supervision of agency personnel and/or local fire officials, and all conditions and requirements imposed by such supervisory officials shall be strictly followed.(3) Prior to removing the tank from the ground, all connected piping and other ancillary equipment shall be emptied, disconnected, and properly plugged, capped, or removed.(4) Storage of removed tanks. (A) After removal, a tank shall be transported from the site within 24 hours of removal, unless prior approval of a longer on-site storage period is obtained from the manager of the appropriate regional office (or the manager's designated representative).(B) The on-site storage of tanks for a period of 24 hours or less shall be in a designated temporary storage area which shall be an adequate distance from known ignition sources and which shall be clearly identified with appropriate barriers and warning signs to restrict access by unauthorized persons.(C) On-site storage of removed tanks for more than 24 hours (when approved by the regional manager), and off-site storage for any period, shall only be allowed in locked, securely fenced, or similarly restricted areas where unauthorized persons will not have access.(D) No later than 24 hours after removal, all removed tanks (regardless of condition) shall be legibly and permanently labeled (in letters at least two inches high) with the name of the former contents, a flammability warning (if applicable), and a warning that the tank is unsuitable for the storage of drinking water or the storage of human or animal food products.(E) The residual vapor levels in any removed tank which is stored at the UST facility shall be maintained at nonexplosive and nonignitable levels for the entire time that the tank remains at the facility.(F) Regardless of where the tank is stored, not later than ten days after the tank has been removed from the ground, any residual liquids or vapors shall be permanently removed to render the tank nonignitable and nonexplosive.(5) Transportation and disposal of removed tanks.(A) The methods and procedures used for the handling, transporting, and disposing of any removed USTs (and parts of such tanks) shall be protective of human health and safety and the environment, and shall be in accordance with all applicable federal, state, and local regulations.(B) Removed tanks (and any parts of such tanks) which have been emptied, thoroughly cleaned of all remaining substances and any remaining residues, and permanently purged of vapors may be appropriately disposed by scrapping, junking, or reusing for purposes unrelated to the underground storage of regulated substances.(C) Prior to transporting any removed tank from the UST facility, the following minimum preparation procedures shall be followed.(i) The remaining regulated substances shall be removed, and visible residues or sediments shall be cleaned from the tank as completely as possible, in accordance with commonly used and accepted industry practices.(ii) Residual vapor levels in the tank shall be reduced to nonexplosive and nonignitable levels, and shall be maintained at such levels during the entire period of transportation.(iii) All holes and openings shall be properly plugged or capped, except for one 1/8-inch diameter vent hole positioned at the top of the tank during transportation.(D) The subsequent reuse of any removed tanks for the underground storage of regulated substances (whether on-site or off-site) shall only be allowed under the provisions of § 334.53 of this title (relating to Reuse of Used Tanks).(6) The tank owner shall develop and maintain a permanent record of the prior location of the removed tank; the date of removal; the substance previously stored; the method of conditioning the tank for removal; the methods of handling, transportation, storing, and disposing of the tank; the names, addresses, and telephone numbers of the person conducting the activities; and any information regarding any known releases from such tank. If the facility owner is not the same person as the tank owner, the tank owner shall provide a copy of such information to the site or facility owner within 30 days after the date of removal.(c) Abandonment in-place. A UST may be permanently removed from service by abandonment in-place in lieu of actual removal from the ground. In addition to the requirements of subsection (a) of this section, the following requirements shall be applicable to the abandonment in-place of USTs.(1) When the UST owner is not the owner of the site or facility where such tank is located, the tank owner is prohibited from abandoning such tank in-place unless the following conditions are met. (A) The tank owner shall provide written notice to the owner of the site or facility for the abandonment in-place prior to initiating the activity.(B) After completion of the abandonment in-place, the tank owner shall provide to the site or facility owner a legible copy of the permanent record of the abandonment, as described in paragraph (3) of this subsection.(2) Any tank that is abandoned in-place shall be filled with a solid inert material as prescribed in this paragraph.(A) Only solid inert materials which are free of any harmful contaminants or pollutants shall be used to fill the tank. Acceptable materials include sand, fine gravel, sand and gravel mixtures, and cement/concrete-based slurries. Other materials such as native soils, drilling muds, and commercially marketed fill materials shall not be used for filling the tank unless the material and filling procedures have been reviewed and approved by the agency in accordance with § 334.43 of this title (relating to Variances and Alternative Procedures).(B) Adequate access openings shall be made in the top of the tank, and the tank shall be filled as completely as possible. Voids and air pockets shall be eliminated.(C) The fill material and filling procedures shall be adequate to assure that:(i) the filled tank will not surface after completion of the filling operation;(ii) any settling or instability of the ground surface subsequent to the abandonment in-place is minimized or eliminated;(iii) the fill materials will form a permanent solid inert filler that can be expected to remain structurally stable in the ground to prevent cave-ins, even after the subsequent deterioration of the tank walls; and(iv) the filled tank and associated piping are disconnected and capped or sealed so as to preclude their future use for any storage or disposal purposes.(3) The tank owner shall develop and maintain a permanent record of the name and address of the tank owner (and site or facility owner, if different); the abandoned tank location; the date of abandonment; the substance previously stored; the method of conditioning the tank for abandonment; release assessment results; the names, addresses, and telephone numbers of the persons conducting the activities; and information regarding the extent of any confirmed releases and any resulting remediation activities. (A) When the tank owner is not the owner of the facility where the tank is located, the tank owner shall provide to the current facility owner a legible copy of the permanent record of the abandonment in-place. Such information shall be provided no later than 30 days after completion of the abandonment in-place.(B) The facility owner shall maintain a permanent record of the tank abandonment in-place in accordance with subsection (f) of this section.(C) Prior to the sale or conveyance of the facility where an abandoned UST is located, the facility owner shall provide written documentation of the tank abandonment information to the succeeding property owner.(d) Change-in-service. In addition to the requirements of subsection (a) of this section, the following requirements shall be applicable for any change-in-service where a UST system storing regulated substances is converted to a system storing materials other than regulated substances.(1) Prior to refilling with materials other than regulated substances, the UST shall be properly emptied, cleaned, and purged of vapors in accordance with a code or standard of practice developed by a nationally recognized association or independent testing laboratory for the stored regulated substance. The procedures for emptying, cleaning, and purging the UST shall be designed to remove as much as possible of the previously stored regulated substances, including all liquids, vapors, sludges, and residues, in a manner that is protective of human health and safety or the environment.(2) A change-in-service where a UST storing regulated substances is to be converted for the storage of either drinking water or food products intended for human consumption is specifically prohibited.(3) Any change-in-service shall be in accordance with all applicable federal, state, and local regulations.(4) The owner shall develop and maintain a permanent record of the location of the UST; the date of the change-in-service; the regulated substance previously stored; the method of conditioning the tank for the change-in-service; the names, addresses, and telephone numbers of the persons conducting the activities; and any information regarding any known releases of regulated substances from such tank. If the facility owner is not the same person as the UST owner, the UST owner shall provide a copy of such information to the facility owner within 30 days after the date of the change-in-service.(5) For the purposes of this section, a UST which has been converted to the storage of materials other than regulated substances (i.e., water) shall be subject to the procedures for temporary removal from service in § 334.54 of this title, except when the stored materials are utilized on a regular basis for beneficial purposes.(e) Site assessment. (1) A site assessment meeting the requirements of this subsection shall be performed by the owner or operator of a UST system in the following situations to determine whether or not a release has occurred: (A) when the site assessment is selected as the method to achieve compliance with the release determination requirements of subsection (a)(6) of this section for a UST which is permanently removed from service on or after September 29, 1989;(B) when the agency determines that a site assessment is necessary at any site or facility where a UST was permanently removed from service prior to September 29, 1989, and where the site assessment or release determination at the time of removal from service was determined to be either nonexistent or inadequate; or(C) when the agency determines that a site assessment is necessary at any site or facility where a release or suspected release may pose a current or potential threat to human health or safety or the environment.(2) The site assessment shall be conducted by qualified personnel possessing the appropriate skills, experience, and competence to perform the assessment in accordance with recognized industry practices and the provisions of this section and shall be supervised by a person who is currently licensed by the Texas Commission on Environmental Quality (TCEQ) as a UST installer or on-site supervisor or currently registered with the TCEQ as a corrective action project manager.(3) Any procedures used for the site assessment must be capable of measuring for the presence of a release from any part of the UST system and, at a minimum, must include measurements for releases at locations where contamination is most likely to be present at the site.(4) The owner or operator shall assure that in selecting the sampling or measurement methods, the sample types, and the sampling or measurement locations, the persons conducting the assessment shall take into consideration the following factors to ensure that the presence of any released regulated substances is detected and quantified: (A) the specific method of removing the UST system from service;(B) the nature and composition of the stored regulated substance;(C) the type and characteristics of the backfill material and surrounding soils;(D) the presence of groundwater, and its depth with relation to the UST system and the surface of the ground; and(E) any other factors that may affect the reliability or effectiveness of the site assessment procedures or techniques.(5) One or more of the following methods may be used for conducting the site assessment and release determination required under this section, provided that such methods are in compliance with the performance standards in paragraphs (2) - (4) of this subsection:(A) collection and analysis of soil samples secured from unsaturated sections of the UST system excavation zone and surrounding soils, where such samples shall be analyzed for major constituents and/or indicator parameters of the stored regulated substance(s);(B) collection and analysis of groundwater samples secured from the UST system excavation zone and surrounding area, where such samples shall be analyzed for all major constituents or indicator parameters of the stored regulated substance(s); and/or(C) any other site assessment or release determination method or procedure which has been reviewed and determined by the agency to detect prior releases of the stored regulated substance(s) in a manner that is no less protective of human health and the environment than the methods described in subparagraphs (A) and (B) of this paragraph, as provided under § 334.43 of this title.(D) The owner or operator must report any suspected or confirmed releases indicated by the site assessment to the agency and comply with all applicable release investigation and corrective action requirements, as prescribed in Subchapter D of this chapter.(f) Records for permanent removal from service. (1) Owners and operators shall maintain records adequate to demonstrate compliance with the requirements of this section, in accordance with § 334.10(b) of this title (relating to Reporting and Recordkeeping).(2) At a minimum, the following records shall be maintained for five years after the UST system is permanently removed from service: (A) records of the release determination or site assessment, in accordance with the requirements in subsection (a)(6)(D)(ii) of this section;(B) records related to the tank removal procedures (as applicable), in accordance with the requirements in subsection (b)(6) of this section;(C) records related to the abandonment in-place of a UST system (as applicable), in accordance with the requirements in subsection (c)(3) of this section; and(D) records related to the change-in-service of a UST system (as applicable), in accordance with the requirement in subsection (d)(4) of this section.(g) Codes of practice. The following cleaning and closure procedures may be used to comply with this section:(1) American Petroleum Institute (API) Recommended Practice 1604, "Closure of Underground Petroleum Storage Tanks;"(2) API Standard 2015, "Requirements for Safe Entry and Cleaning of Petroleum Storage Tanks;"(3) API Recommended Practice 2016, "Guidelines and Procedures for Entering and Cleaning Petroleum Storage Tanks;"(4) API Recommended Practice 1631, "Interior Lining and Periodic Inspection of Underground Storage Tanks;" and(5) National Fire Protection Association Standard 326, "Standard for the Safeguarding of Tanks and Containers for Entry, Cleaning, or Repair."30 Tex. Admin. Code § 334.55
The provisions of this §334.55 adopted to be effective September 29, 1989, 14 TexReg 4714; amended to be effective January 2, 1995, 19 TexReg 10104; amended to be effective November 23, 2000, 25 TexReg 11442; amended to be effective November 18, 2004, 29 TexReg 10532; Amended by Texas Register, Volume 43, Number 21, May 25, 2018, TexReg 3427, eff. 5/31/2018