Section 117.2030 - Operating Requirements(a) The owner or operator shall operate any unit subject to § 117.2010 of this title (relating to Emission Specifications) in compliance with those requirements.(b) All units subject to § 117.2010 of this title must be operated so as to minimize nitrogen oxides (NOX) emissions, consistent with the emission control techniques selected, over the unit's operating or load range during normal operations. Such operational requirements include the following. (1) Each boiler must be operated with oxygen (O 2), carbon monoxide (CO), or fuel trim.(2) Each boiler and process heater controlled with forced flue gas recirculation (FGR) to reduce NOX emissions must be operated such that the proportional design rate of FGR is maintained, consistent with combustion stability, over the operating range.(3) Each unit controlled with post-combustion control techniques must be operated such that the reducing agent injection rate is maintained to limit NOX concentrations to less than or equal to the NOX concentrations achieved at maximum rated capacity.(4) Each stationary internal combustion engine controlled with nonselective catalytic reduction must be equipped with an automatic air-fuel ratio (AFR) controller that operates on exhaust O2 or CO control and maintains AFR in the range required to meet the engine's applicable emission limits.(5) Each stationary internal combustion engine must be checked for proper operation according to § 117.8140(b) of this title (relating to Emission Monitoring for Engines).(c) No person shall start or operate any stationary diesel or dual-fuel engine for testing or maintenance between the hours of 6:00 a.m. and noon, except: (1) for specific manufacturer's recommended testing requiring a run of over 18 consecutive hours;(2) to verify reliability of emergency equipment (e.g., emergency generators or pumps) immediately after unforeseen repairs. Routine maintenance such as an oil change is not considered to be an unforeseen repair; or(3) firewater pumps for emergency response training conducted in the months of April through October.30 Tex. Admin. Code § 117.2030
The provisions of this §117.2030 adopted to be effective June 14, 2007, 32 TexReg 3206