(a)Applicability.This section shall apply to 1990 and subsequent model passenger cars, light-duty trucks, medium-duty vehicles, and motor vehicle engines used in such vehicles. This section shall apply to medium-duty vehicles certified to the GHG emission standards of section 95663, title 17, for GHG emission control components, as set forth in 40 CFR 1037.120, as amended October 25, 2016, incorporated by reference herein. The warranty period shall begin on the date the vehicle is delivered to an ultimate purchaser, or if the vehicle is first placed in service as a "demonstrator" or "company" car prior to delivery, on the date it is first placed in service.
(b)General Emissions Warranty Coverage.The manufacturer of each motor vehicle or motor vehicle engine shall warrant to the ultimate purchaser and each subsequent purchaser that the vehicle or engine is:
(1) Designed, built, and equipped so as to conform with all applicable regulations adopted by the Air Resources Board pursuant to its authority in chapters 1 and 2, part 5, division 26 of the Health and Safety Code; and(2) Free from defects in materials and workmanship which cause the failure of a warranted part to be identical in all material respects to the part as described in the vehicle or engine manufacturer's application for certification, including any defect in materials or workmanship which would cause the vehicle's on-board diagnostic malfunction indicator light to illuminate, for a period of three years or 50,000 miles, whichever first occurs; and(2.1) For GHG emission control components in Phase 2 medium-duty vehicles (2021 and subsequent model years) certified to the GHG emission standards of section 95663, title 17, free from defects in materials and workmanship which cause the failure of a warranted part to be identical in all material respects to the part as described in the vehicle or engine manufacturer's application for certification, for a period of five years or 50,000 miles (except tires), whichever first occurs, and for tires only, a period of two years or 24,000 miles, whichever first occurs.(3) Free from defects in materials and workmanship which cause the failure of a warranted part described in section (c) below for seven years or 70,000 miles, whichever first occurs. The requirements of this subsection (3) shall not apply to GHG emission control components in Phase 2 medium-duty vehicles certified to the GHG emission standards of section 95663, title 17.(c)"High-Priced" Warranted Parts. (1) Each manufacturer shall identify in its application for certification the "high-priced" warranted parts which are: (A) For 1990 through 2007 model year vehicles: [i] included on the Board's "Emissions Warranty Parts List" as last amended February 22, 1985, incorporated herein by reference, and; [ii] have an individual replacement cost at the time of certification exceeding the cost limit defined in section (c)(3);(B) For 2008 and subsequent model year vehicles: [i] subject to coverage as a warranted part in section (b)(2) above, and; [ii] have an individual replacement cost at the time of certification exceeding the cost limit defined in section (c)(3).(2) The replacement cost shall be the retail cost to a vehicle owner and include the cost of the part, labor, and standard diagnosis. The costs shall be those of the highest-cost metropolitan area of California.(3) The cost limit shall be calculated using the following equation: Cost limitn= $300 x (CPIn-2 / 118.3) where:
Cost limitn is the cost limit for the applicable model year of the vehicle rounded to the nearest ten dollars.
n is the model year of the new vehicles.
n-2 is the calendar year two years prior to the model year of the new vehicles.
CPI is the annual average nationwide urban consumer price index published by the United States Bureau of Labor Statistics.
(4) The cost limit shall be revised annually by the Executive Officer. The highest-cost metropolitan area in California shall be identified by the Executive Officer for use in this section. If a manufacturer seeks certification of a vehicle before the applicable annual average CPI is available, the cost limit shall be calculated using the average of the monthly nationwide urban CPI figures for the most recent twelve month period for which figures have been published by the United States Bureau of Labor Statistics.(5) Each manufacturer shall submit to the Executive Officer the documentation used to identify the "high-priced" warranted parts required in this section. The documentation shall include the estimated retail parts costs, labor rates in dollars per hour, and the labor hours necessary to diagnose and replace the parts. The documentation is not required for vehicles certified before January 24, 1991.(6) The Executive Officer may reject or require modification of the manufacturer's list of "high-priced" warranted parts to ensure that such list includes all emission-related parts whose replacement cost exceeds the cost limit defined in section (c)(3)(d) Subject to the conditions and exclusions of section (i), the warranty on emission-related parts shall be interpreted as follows:(1) Any warranted part which is not scheduled for replacement as required maintenance in the written instructions required by section (e) shall be warranted for the applicable warranty period defined in section (b)(2) or (3). If any such part fails during the period of warranty coverage, it shall be repaired or replaced by the vehicle or engine manufacturer according to section (d)(4) below. Any such part repaired or replaced under the warranty shall be warranted for the remaining warranty period.(2) Any warranted part which is scheduled only for regular inspection in the written instructions required by section (e) shall be warranted for the applicable warranty period defined in section (b)(2) or (3). A statement in such written instructions to the effect of "repair or replace as necessary" shall not reduce the period of warranty coverage. Any such part required or replaced under warranty shall be warranted for the remaining warranty period.(3) Any warranted part which is scheduled for replacement as required maintenance in the written instructions required by section (e) shall be warranted for the period of time or mileage, whichever first occurs, prior to the first scheduled replacement point for that part. If the part fails prior to the first scheduled replacement, the part shall be repaired or replaced by the vehicle or engine manufacturer according to section (d)(4) below. Any such part required or replaced under warranty shall be warranted for the remainder of the period prior to the first scheduled replacement point for the part.(4) Repair or replacement of any warranted part under the warranty provisions of this article shall be performed at no charge to the vehicle or engine owner at a warranty station, except in the case of an emergency when a warranted part or a warranty station is not reasonably available to the vehicle or engine owner. In an emergency, repairs may be performed at any available service establishment, or by the owner, using any replacement part. The manufacturer shall reimburse the owner for his or her expenses including diagnostic charges for such emergency repair or replacement, not to exceed the manufacturer's suggested retail price for all warranted parts replaced and labor charges based on the manufacturer's recommended time allowance for the warranty repair and the geographically appropriate hourly labor rate. A vehicle or engine owner may reasonably be required to keep receipts and failed parts in order to receive compensation for warranted repairs reimbursable due to an emergency, provided the manufacturer's written instructions required by section (e) advise the owner of this obligation.(5) Notwithstanding the provisions of subsection (d)(4) above, warranty services or repairs shall be provided at all of a manufacturer's dealerships which are franchised to service the subject vehicles or engines.(6) The vehicle or engine owner shall not be charged for diagnostic labor which leads to the determination that a warranted part is defective, provided that such diagnostic work is performed at a warranty station.(7) The vehicle or engine manufacturer shall be liable for damages to other vehicle components proximately caused by a failure under warranty of any warranted part.(8) Throughout the vehicle or engine's warranty period defined in section (b)(2) and (b)(3), the vehicle or engine manufacturer shall maintain a supply of warranted parts sufficient to meet the expected demand for such parts. The lack of availability of such parts or the incompleteness of repairs within a reasonable time period, not to exceed 30 days from the time the vehicle or engine is initially presented to the warranty station for repair, shall constitute an emergency for purposes of section (d)(4) above.(9) Any replacement part may be used in the performance of any maintenance or repairs. Any replacement part designated by a manufacturer may be used in warranty repairs provided without charge to the vehicle owner. Such use shall not reduce the warranty obligations of the vehicle or engine manufacturer, except that the vehicle or engine manufacturer shall not be liable under this article for repair or replacement of any replacement part which is not a warranted part (except as provided under section (d)(7) above).(10) Any add-on or modified part exempted by the Air Resources Board from the prohibitions of Vehicle Code section 27156 may be used on a vehicle or engine. Such use, in and of itself, shall not be grounds for disallowing a warranty claim made in accordance with this article. The vehicle or engine manufacturer shall not be liable under this article to warrant failures of warranted parts caused by the use of such an add-on or modified part.(11) The Executive Officer may request and, in such case, the vehicle or engine manufacture shall provide, any documents which describe the manufacturer's warranty procedures or policies.(e) Each manufacturer shall furnish with each new vehicle or engine, written instructions for the maintenance and use of the vehicle or engine by the owner, and the instructions shall be consistent with this article and applicable regulations in article 2 of this subchapter.(f) Each manufacturer shall furnish with each new vehicle or engine a list of the "high-priced" warranted parts established by section (c).(g) Prior to the 2001 model year, each manufacturer shall submit the documents required by sections (c)(5), (e), and (f) with the manufacturer's preliminary application for new vehicle or engine certification for approval by the Executive Officer. For 2001 and subsequent model years, each manufacturer shall submit the documents required by section (c)(5), (e), and (f) with the Part 2 Application for Certification pursuant to the "California 2001 through 2014 Model Criteria Pollutant Exhaust Emission Standards and Test Procedures and 2009 through 2016 Model Greenhouse Gas Exhaust Emission Standards and Test Procedures for Passenger Cars, Light-Duty Trucks, and Medium-Duty Vehicles," incorporated by reference in title 13, CCR section 1961(d), the "California 2015 through 2025 Model Year Criteria Pollutant Exhaust Emission Standards and Test Procedures and 2017 and Subsequent Model Year Greenhouse Gas Exhaust Emission Standards and Test Procedures for Passenger Cars, Light-Duty Trucks, and Medium-Duty Vehicles," incorporated by reference in title 13, CCR section 1961.2(d), or the "California 2026 and Subsequent Model Year Criteria Pollutant Exhaust Emission Standards and Test Procedures for Passenger Cars, Light-Duty Trucks, and Medium Duty Vehicles," incorporated by reference in title 13, CCR section 1961.4(c)(1), as applicable. The Executive Officer may reject or require modification of any of the documents required by sections (c), (e), and (f) for, among other reasons, incompleteness and lack of clarity. Approval by the Executive Officer of the documents required by sections (c), (e), and (f) shall be a condition of certification. The Executive Officer shall approve or disapprove the documents required by sections (c), (e), and (f) within 90 days of the date such documents are received from the manufacturer. Any disapproval shall be accompanied by a statement of the reasons thereof. In the event of disapproval, the manufacturer may petition the Board to review the decision of the Executive Officer.(h)Vehicle Inspection Program.(1) This section applies to 1990 and subsequent model passenger cars, light-duty trucks, and medium-duty vehicles which fail to pass a smog check inspection pursuant to Health and Safety Code section 44012 after the warranty period of three years or 50,000 miles, whichever occurs first, has expired, but before the warranty period of seven years or 70,000 miles, whichever occurs first, has expired. The provisions of this section shall be contained in the warranty statement required pursuant to title 13, CCR section 2039.(2) The owner of a vehicle which fails an inspection during the period described in section (h)(1) may choose to have the vehicle repaired at a warranty station. (A) If the warranty station identifies that the inspection failure was caused by the failure or malfunction of a "high-priced" part defined in section (c), then the vehicle manufacturer shall be liable for expenses involved in detecting and correcting the part failure or malfunction, unless the warranty station demonstrates that the part failure or malfunction was caused by abuse, neglect, or improper maintenance as specified in section (i).(B) If the warranty station demonstrates that the inspection failure was caused by one or more conditions excluded from warranty coverage pursuant to section (i), the vehicle owner shall be liable for all diagnostic and repair expenses. Such expenses shall not exceed the maximum repair costs permissible under the inspection program.(C) If the warranty station determines that the inspection failure was caused by one or more defects covered under warranty pursuant to these regulations and in combination with one or more conditions excluded from warranty coverage pursuant to section (i), then the vehicle owner shall not be charged for the diagnostic and repair costs related to detecting and repairing the warrantable defects.(3) In the alternative, the owner of a vehicle which fails the inspection may choose to have the vehicle repaired at other than a warranty station. If a warrantable defect is found, the vehicle owner may deliver the vehicle to a warranty station and have the defect corrected free of charge. The vehicle manufacturer shall not be liable for any expenses incurred at a service establishment not authorized to perform warranty repairs, except in the case of an emergency as defined in section (d)(4). If the vehicle owner chooses to have a warrantable defect repaired at other than a warranty station, the upper cost limit pursuant to Health and Safety Code section 44017 shall not apply to the repair.(i)Exclusions.The repair or replacement of any warranted part otherwise eligible for warranty coverage under sections (d) and (h) shall be excluded from such warranty coverage if the vehicle or engine manufacturer demonstrates that the vehicle or engine has been abused, neglected, or improperly maintained, and that such abuse, neglect, or improper maintenance was the direct cause of the need for the repair or replacement of the part.
Cal. Code Regs. Tit. 13, § 2037
1. New section filed 1-16-79; effective thirtieth day thereafter (Register 79, No. 3).
2. Amendment filed 11-26-90; operative 12-26-90 (Register 91, No. 3).
3. Amendment of section heading, subsection (g) and NOTE filed 10-28-99; operative 11-27-99 (Register 99, No. 44).
4. Amendment filed 11-9-2007; operative 11-9-2007 pursuant to Government Code section 11343.4 (Register 2007, No. 45).
5. Amendment of subsection (g) filed 8-7-2012; operative 8-7-2012 pursuant to Government Code section 11343.4 (Register 2012, No. 32).
6. Amendment of subsection (a) and amendment of NOTE filed 12-5-2014; operative 12-5-2014 pursuant to Government Code section 11343.4(b)(3) (Register 2014, No. 49).
7. Editorial correction of HISTORY 6 (Register 2014, No. 50).
8. Amendment of subsection (a), new subsection (b)(2.1) and amendment of subsection (b)(3) filed 2-7-2019; operative 4-1-2019 (Register 2019, No. 6).
9. Amendment of subsection (g) filed 11-30-2022; operative 11-30-2022 pursuant to Government Code section 11343.4(b)(3) (Register 2022, No. 48). Note: Authority cited: Sections 38501, 38505, 38510, 38560, 39600 and 39601, Health and Safety Code. Reference: Sections 38501, 38505, 38510, 38560, 43106, 43204, 43205, 44004, 44010, 44011, 44012, 44015 and 44017, Health and Safety Code.
1. New section filed 1-16-79; effective thirtieth day thereafter (Register 79, No. 3).
2. Amendment filed 11-26-90; operative 12-26-90 (Register 91, No. 3).
3. Amendment of section heading, subsection (g) and NOTE filed 10-28-99; operative 11-27-99 (Register 99, No. 44).
4. Amendment filed 11-9-2007; operative 11-9-2007 pursuant to Government Code section 11343.4 (Register 2007, No. 45).
5. Amendment of subsection (g) filed 8-7-2012; operative 8-7-2012 pursuant to Government Code section 11343.4 (Register 2012, No. 32).
6. Amendment of subsection (a) and amendment of Note filed 12-5-2014; operative 1/1/2015 pursuant to Government Code section 11343.4(b)(3) (Register 2014, No. 49).
7. Editorial correction of History 6 (Register 2014, No. 50).
8. Amendment of subsection (a), new subsection (b)(2.1) and amendment of subsection (b)(3) filed 2-7-2019; operative 4/1/2019 (Register 2019, No. 6).
9. Amendment of subsection (g) filed 11-30-2022; operative 11/30/2022 pursuant to Government Code section 11343.4(b)(3) (Register 2022, No. 48).